If you are facing any of those, do not worry. I don't recall the deadman switch working like that, I thought it would only stop the engine if the tractor was moving. Established in 2009, we are the largest online community of Kubota tractor and equipment owners. Here are the symptoms: It could still be the battery. JavaScript is disabled. I had it going on Wednesday for about 20 to 30 minutes pushing snow, and then came back a few hours later to do some more work, and it wouldn't start.
L3400 won't start - what might be wrong? - TractorByNet Always consult equipment operator's manual and follow safety instructions before operating or servicing any tractor or equipment, or attempting any task. For a better experience, please enable JavaScript in your browser before proceeding.
Kubota Tractor won't startTry This - YouTube Replaced the stop relay but still get same results. Checked battery, fuses, fuel and all are good. Best Evergreen Trees to Plant In New York, 10 Evergreen Trees to Plant in North Carolina, 5 Common Problems with John Deere 4120 (Solutions Included), Most Common Problems with John Deere 5045E (Solutions Added), 6 Most Common Problems with Massey Ferguson 240, 5 Most Common Problems with Bobcat T770 (Solutions Included), Most Common Problems with John Deere 750 (Solutions Added). The fuel solenoid shuts off fuel or engages linkage that controls fuel distribution. If the diesel fuel pours as it leaves the line, there may be something clogged in the line. what I found was that not enough.
kubota L3500 cranks but won't start : r/tractors - reddit Continue with Recommended Cookies. Check for voltage there and if not figure out why. For almost a Month I could not start the Kubota Tractor, come to find out after testing. 64. Unfortunately, not all tractor is perfect. JavaScript is disabled. The consent submitted will only be used for data processing originating from this website. 62. And yes, some of them can be solved at home. The other switches to look for are on the clutch pedal, on the range shifter if it is a standard shift or one just above the center of the floor board if it is a hydrostat. To test circuits, fuses and switches use a multimeter tester you can get one here: http://amzn.to/2A5ihXN , you check continuity of circuitssimple example: if you have a standard fuse you put the test wires on either end if fuse is blown it wont show on your meter, if its good needle will go up showing that current can flow through it(Continuity) if your multi-meter doesn't have a dedicated continuity test mode, you can still perform a continuity test. Always consult equipment operator's manual and follow safety instructions before operating or servicing any tractor or equipment, or attempting any task. Kubota has no idea what it is, and i'm not going to the place that gave me that quote, we jumped it for now. Can it be solved at home? An example of data being processed may be a unique identifier stored in a cookie. What happens here is, that every other gear works fine and when you try to use that particular gear. Is your 3400 a hydrostat or standard shift transmission? I got this tractor from my grand father that passed last year, about 2800 hours on it, my fathers friend helped tow it over and has been sitting beside the RV under our car part since, it has been ran a few times with no issues. You have found you high resistance problem.
L3400 won't start. Safety switch. Help please! - OrangeTractorTalks What this does is, it pulls the fuel and takes it to the engine from the fuel tank. Kubota L3400DT-IF 4 WD Tractor, Serial . Checking Wheel Bolt Torque. No one here can tell you much more without more information from trouble shooting. Do they at least give you a reach around? Join us in searching for a Kubota diesel that will not start in the cold weather. Turned on the engine and let it idle for a few minutes until it sounded better. The air cleaner can be clogged or an unadjusted engine valve can cause this problem. Overall, it increases the productivity of the tractor. JavaScript is disabled. Removed the solenoid and the tractor started, had to restrict airflow since the fuel solenoid was not connected.. It may not display this or other websites correctly. People need to turn off the vehicle to operate it again. You must log in or register to reply here. . Mostly this creates the problem. If it is, you need to replace it. Last week i got it out to pull a small tree and did great, put it back under the car port, came back the next day, started right up, drove about 50feet and quit, the engine turns over fine, but won't fire. i even bushogged with it for 3 hours. Manage Settings tank is 3/4 full, new fuel filter, my fathers friend came over and sprayed diesel in the intake and it started running a bit but soon as he stopped, engine stopped. Ask an Expert Car Questions Agriculture and Farm Equipment This answer was rated: Kubota L3400 starter wont engage. I disconnected the two wires and plugged them into themselves and it started right away now it doesn't turn over at all. called kubota and other parts places, they have no idea what it is, can't find a pic of it anywhere, so we just put a switch on it for now. Firstly, check the fuel line. Kubota enthusiasts, hobbyists, and fans! Battery is good. Kubota L3400 2006 will turn over but not start. Fuel tank is half full. follow that with all the safety switches in the path to engaging the start relay. I figured I needed to bleed the system. Kubota L3400 tractor overview. 250 an hour?!? Please post back. else. Still no idea what to do next. JavaScript is disabled. If you have 12V then have someone turn the key on while you listen to see if it starts. Did you run it out of fuel? My relatively new (71 hours) Kubota L3400 will not start. Put new solenoid on.no start. if it is very low there, then by all means clean/repair the connections. Fix all the connections battery has with other parts of the vehicle.
Will it start challenge! Cold weather starting of Kubota equipment what does the volt meter say when you try to start it. OrangeTractorTalks brings together Kubota enthusiasts from around the world, into one place, purpose built just for them. Not starting, shutting off after some time, POT not turning on, and RPM slowing down are the common kubota l3400 problems. You need to get a service book for this tractor with a wiring diagram.
TractorData.com Kubota L3400 tractor information If not then your solenoid could be bad if so then you have bigger issues that need deeper troubleshooting. The other was the switch that senses the neutral position of the hydro pedal. 63. I had two separate things affect starting on mine. You must log in or register to reply here. THe tractor will turn over but will not start. TONY, DID YOU CHECK THE PTO LEVER, CLUTCH PEDDLE SWITCH AND HIS THE BATTERY CHARGED UP GOOD NO LOOSE CONECTIONS AND SAFETY SWITCH UNDER SEAT. For a better experience, please enable JavaScript in your browser before proceeding. Getting fuel and hot battery. You must log in or register to reply here. The more I read about fuel solenoid the more I think my tractor non-run problem may be related to the fuel solenoid. It is hard to believe that two little wires control the whole contraption. Evacuator Valve. if your Kubota tractor won't start watch this video - and try this first. if it is very low there, then by all means clean/repair the connections. JavaScript is disabled. I'm smart and relatively mechanically inclined, but I don't have a lot of experience with diesel or tractors, much less diesel tractors. Try rocking the hydrostatic pedal back and forth, allowing it to return to it's functional position on it's own. Read somewhere that the fuel solenoid can cause the issue. Both have to be in neutral. If the problem does not solve yet, replace the fuel filter. My 3400 HSt was new in dec 2006 and recently developed an intermittent starting problem, sometimes it would go etc.. Many thanks. Secondly, check and inspect the fuel filter.
Kubota L3540 Won't Start : r/kubota - reddit.com LOL. Ran the engine for 30 seconds and turned it off. Today it won't start. It is a multipurpose tractor that you can use in various ways. Crack a line at an injector and see if you have fuel when cranking the engine. Disconnect the line which connects the fuel filter and the fuel pump. Aug 9, 2021. You can find it by following the fuel line back from the injection pump and the first thing you run into with wires is likely the lift pump. When you load heavier the RPM shows down to an almost shiftless situation. Welcome. My relatively new (71 hours) Kubota L3400 will not start. Was asked to take a look at this problem and was solved by installing Starter Relay Kit That he bought from john deer but will work on any tractor I would think. I am a little suspicious of the deadman switch, because lately when I've gotten off the tractor to move something or whatever, the engine will stop. I turned the air vent cock to open. .Sometimes it starts, then dies.
L3400 won't start - help, please? - TractorByNet Fuel flow issues are the most common reason for Kubota L3400 to stop working after running for a while. Anything and everything about Kubota. With the key in, turning it to the left does nothing (no lights on dash, etc), Turning the key to start does absolutely nothing, Turning the key to the spot to the right of off, but not all the way to start makes some sort of whining/humming sound like it's trying to do something but it can't. I followed the ignition procedure, indicator lights are fine, but when I turn the key I just get one beep followed by nothing, no clicks, nothing. I followed the ignition procedure, indicator lights are fine, but when I turn the key I just get one beep followed by nothing, no clicks, nothing. My Kubota l3400 tractor won't start. Sounds like an obstruction or bad lift pump. Maybe you just typed it wrong - pto needs to be. Or your fuel system needs bleed out so leave the injector line loose and crank for a while. What does hang up is the PTO safety hookup on the PTO lever itself ( right side of wheel). Kansas, Butler county, Just east of DooDah. For a better experience, please enable JavaScript in your browser before proceeding. If the actual problem is this, it should be solved by this method. You are using an out of date browser.
If its still on, check for the cable which runs from the PTO shift and goes into the transmission case under the seat. This problem occurs mostly with heavier loads. I had it going on Wednesday for about 20 to 30 minutes pushing snow, and then came back a few hours later to do some more work, and it wouldn't start. Dead battery? My tractor is suffering this now, but I do know where to look to get it back running. Buts that's where the real. You will feel like this is a new vehicle you are running. So run the battery voltage test again. Do it for at least fine munities. Check the Deadman switch under the seat? Battery fully charged, Curtis B., Technician 44,329 Curtis B., Technician 44,329 Satisfied Customers Or bad battery connection(s). L3450DT-GST, Woods FEL, B7100 HSD, FEL, 60" SB, 743 Bobcat with V2203, and more. I tried the solution proposed by crbr, rocking the transmission pedal - and it worked - made my day! If it is standard or Shuttle shift , there is a small micro-switch for the neutral of the Shuttle Shifter that does not make contact sometimes , I had to tweak mine slightly (micro-switch contact) once to get it to work correctly . Turn the dial to the lowest setting in the resistance mode in the ohms portion of the meter. But today when I turned the key to start, no click, only the sound of the starter turning. So, if there is any link of blockage in it, it can also create a problem. It could be your fuel pump, but more likely it's your solenoid. Any thoughts? Battery fully charged, clicks when key is turned, but not engaging or spinning. You have found you high resistance problem. Open it, start it and let it run for a few minutes then close it. Or maybe one of the PTOs are engaged?
Kubota Starting Problems - YouTube Welcome. Thank you Wolfman. Charged the battery, check the continuity on the fuses, traced power to the starter Ask an Expert Car Questions Agriculture and Farm Equipment Is the concern it will not crank or it will not start? Might even be your key switch which controls the solenoid. It appears to be in Neutral, but is not and will not start after I turned the switch off. I always heard a click when when I turned on the key. Thats where I would start, back on the battery. If there is any water mixed with the oil then the engine can stall. The dead man switch on my fwd/rev pedal is 100% my culprit for no crank no start. 63. The Shuttle Shift lever is stuck in the middle- it will not go into H/L/Reverse. My Kubota l3400 tractor won't start. It should solve the problem. You're not getting fuel to START the machine because they tie that pull in coi l into the safety switches in the START circuit. You will find the downside of the cable. Then I tried to continue mowing, but I only made it down the hill and the tractor stalled as I made the turn. You are using an out of date browser. You can face problems like the PTO not turning off even when the PTO lever is shifted to disengage. I got this tractor from my grand father that passed last year, about 2800 hours on it, my fathers friend helped tow it over and has been sitting beside the RV under our car part since, it has been ran a few times with no issues. It was fine then.
Kubota L3400 died/won't start. I have a lead. Am I right? Battery is good. Removed the solenoid and the tractor started, had to restrict airflow since the fuel solenoid was not connected.. If the tractor starts off good, works for some time, and suddenly stops while in use, the most common reason is fuel starvation. We and our partners use data for Personalised ads and content, ad and content measurement, audience insights and product development. Two weeks ago is the last time I used my L3400. The first time it happened, it was 10 minutes before I figured it out. Sometimes it well run for a few seconds other times a few minutes. If voltages are all good when attempting a start, but starter will not engage, then battery voltage is not getting to the starter or the return path is high resistance/open. Changing Engine Oil. Read somewhere that the fuel solenoid can cause the issue. Thanks to all of you who responded. To know in detail, read on. 2023 TractorByNet.com | TractorByNet is a registered trademark of IMC Digital Universe, Inc. Other trademarks on this page are the property of their respective owners. Press J to jump to the feed.
My Kubota L3400 is failing to start. When key is turned to the first Here are some of them you can face with the solution with it. The fuel solenoid is not engaging. Thanks for this threadI was packing up today and this happenednever thought to mess with the pedal until I read this and it started up after a couple of pushes. Some times the solenoid engages other times not. This happens infrequently enough for me to forget each time, and I just sit there with a puzzeled look on my face for about 30 seconds. Most failures to start with what you have described is from a faulty safety switch or just being out of adjustment. For a better experience, please enable JavaScript in your browser before proceeding. Anyone have any ideas on what to do next?
The battery is brand new. RUBYRUSS only posted a day ago that there was a problem with his L3200. Always consult equipment operator's manual and follow safety instructions before operating or servicing any tractor or equipment, or attempting any task. Checking Engine Start System. Check that the fuel shutoff solenoid is getting voltage before you go blaming the pump. I have a Kubota L3400 with Manual transmission, 4WD. 1. Create an account to follow your favorite communities and start taking part in conversations. The dash lights come on, but when I turn the key all the way there is no click or response at all from the starter.
We and our partners use cookies to Store and/or access information on a device. This way you will get to know if the battery is dead. Kubota is one of the most reliable agricultural vehicles to choose from. Kubota L3400 is a farmers tractor which is a very vital part for some of them. Any chance a pto is engaged? Always consult equipment operator's manual and follow safety instructions before operating or servicing any tractor or equipment, or attempting any task.
Lights can still work with a dead (actually low voltage) battery. Cleaning Air Cleaner Element [Single Element Type] 63. Is the large wire on the starter near 12.6 volts? The hold in coil is usually tied into low oil pressure, high temperature, sensors to shut the engine down if there is a problem develop when it's already running Shutting of Suddenly Arter Working for a While. With the wires plugged into each other you have the tractor thinking that the PTO is always disengaged, therefore it will start with the PTO engaged. It is hard to believe that two little wires control the whole contraption. To fix this problem, you need to lean the fuel bowl first. If you would like to change your settings or withdraw consent at any time, the link to do so is in our privacy policy accessible from our home page.. Hey guys. Try to understand what is the problem first. Reading battery voltage with no load, does not tell the whole story. Don't really have that for something that doesn't get used much. My pantleg occasionally catches the PTO lever on my L3400. 2023 TractorByNet.com | TractorByNet is a registered trademark of IMC Digital Universe, Inc. Other trademarks on this page are the property of their respective owners. Create an account to follow your favorite communities and start taking part in conversations. So, you need to check the battery first if you are facing this kind of problem. Not being able to use any particular gear is not a common problem, but it occurs sometimes. Use an air compressor to flush out if anything is clogged. Thirdly, the problem can be in the fuel injector pump. Make sure there is good voltage at the lift pump. then put the leads on the clamp connections and read it there. Mine has a switch for each of the two gear shift levers. Press question mark to learn the rest of the keyboard shortcuts. The safety switch on the foot pedal has been a problem. For a better experience, please enable JavaScript in your browser before proceeding. Thanks for the replies. Mechanic's Assistant: What is the complete model and serial number of your machine?
L3400 won't start after trying to bleed fuel system. - OrangeTractorTalks If your Kubota diesel engine does not start, begin by confirming that your electrical and fuel delivery systems are performing properly.
L3200 Won't Start - Help!! | OrangeTractorTalks - Everything Kubota 61. For almost a Month I could not start the Kubota Tractor, come to find out after testing every switch and relay on the tractor it is a plunger switch on the what Kubota calls the (speed control pedal in the owners manual) (they should call it the Forward/Reverse pedal) Translators ?